Menu
Your Cart
M - F | 8am - 5pm (EST) | Phone: +1 239-461-5522

FL08 Solar 5W/10W/20W/30W Sign Light System (2 Fixtures)

FL08 Solar 5W/10W/20W/30W Sign Light System (2 Fixtures)
FL08 Solar 5W/10W/20W/30W Sign Light System (2 Fixtures)
FL08 Solar 5W/10W/20W/30W Sign Light System (2 Fixtures)
FL08 Solar 5W/10W/20W/30W Sign Light System (2 Fixtures)
FL08 Solar 5W/10W/20W/30W Sign Light System (2 Fixtures)
FL08 Solar 5W/10W/20W/30W Sign Light System (2 Fixtures)
FL08 Solar 5W/10W/20W/30W Sign Light System (2 Fixtures)
FL08 Solar 5W/10W/20W/30W Sign Light System (2 Fixtures)
FL08 Solar 5W/10W/20W/30W Sign Light System (2 Fixtures)
FL08 Solar 5W/10W/20W/30W Sign Light System (2 Fixtures)
FL08 Solar 5W/10W/20W/30W Sign Light System (2 Fixtures)
$820.00

Available Options

A solar powered sign and billboard light system is a cost effective lighting solution to illuminating signs in remote locations. These easy to install system can be installed quickly, without the need of trenching electric cables. 

This solar sign light system is supplied with two light fixtures offered in 5 Watts, 10 Watts, 20 Watts or 30 Watts. The kit includes necessary equipment including the solar panel, batteries, MPPT charge controller, battery enclosure, interconnecting cables, and solar panel mounting hardware.

You can select a system that will allow the lights to illuminate for up to 8 hours, or dusk to dawn. Other options are available upon request. For systems with a maximum of 8 hours illumination; the illumination duration can be split in to two periods. For example, illuminating for 4 hours after sunset and then 4 hours before sunrise, or any other two period 8 hour combination.

Please note that the installation location, desired light fixture power (Wattage), as well as the illumination time will determine the appropriate sized solar panel and batteries for your system. Please refer to the zone map and options table below, and select the correct system option from the drop down bar above.

Choose your System
 

1 - Using the map below as a reference, determine what zone your installation site is located in

Solar Exposure Map US

2 - Using the table below, determine what system option you should select. Choose your desired lamp power, and illumination period within your zone. The point where the two intersect will be the system option you require.

Options Table - 2 Light Fixture

For installation sites in zone 4 or outside of the United States, please contact our sales department for system requirements and pricing. The zone map above is based on estimations and may not be accurate for all areas. For the most accurate solar panel sizing we suggest contacting our sales department. If you require a system with an illumination time other than 8 hours or dusk to dawn, please contact our sales department.

Technical Specifications
 

Performance
Manufactured in an ISO9001:2008 'Quality Assured' facility.
Illumination time can be up to 8 hours or dusk to dawn.
Up to 3 nights autonomy (based on 15 hours illumination).
Based on the lights mounted 6' from the face of the sign, this system can illuminate signs up to:
2 x 5W: Up to 12' x 8'
2 x 10W: Up to 16' x 10'
2 x 20W: Up to 18' x 12'
2 x 30W: Up to 24' x 12'

Light Fixture
Supplied with two LED light fixtures
Offered in 5 Watts, 10 Watts, 20 Watts or 30 Watts.
5 Watt light: 665 lumens
10 Watt light: 1330 lumens
20 Watt light: 2660 lumens
30 Watt light: 3990 lumens
LED efficiency is 133 LM / Watt
LED color temperature is 5700K
IP65 Weather rating.
Aluminum, PC, and steel construction.
Desired wattage must be selected at time of purchase.
Light wattage cannot be changed after receipt.
Each light fixture is supplied with 20’ (6m) of cable.
Light fixture cable can be extended upon request.
Light cable is fitted with plug for easy connection to battery enclosure.
Dimensions are approx. 7” x 7.3” x 1.6”
Color of fixture is bronze.

Battery
24 Volt DC system
System is supplied with two 12V batteries connected in series.
Battery capacity varies depending on light power and illumination time.
Capacity options include 18Ah, 32Ah, 55Ah, 105Ah & 198Ah.
Typical life expectancy is between 3 to 5 years.

Battery Box
Supplied with outdoor rated, weather proof battery enclosure.
Size and model of battery enclosure varies based on batteries supplied.
Battery enclosure options include BE02, BE03 & BE05.
All battery enclosures are lockable with the use of a padlock (not included).
Outlets are installed on BE02 & BE03 enclosures for “plug & play” connections.
Battery enclosures are constructed from galvanized steel, with a gray painted finish.
BE02 dimensions: 9.9” x 15.75” x 8.9”
BE03 dimensions: 21.25” x 15.4” x 11.2”
BE05 dimensions: 20.5" x 13.6" x 33"

Solar Panel
Supplied with an aluminum framed glass faced solar panel
Solar panel size and power (Wattage) varies depending on light power, and installation location.
Solar panel(s) are supplied with a pair of mounting triangles for mounting on to flat horizontal or vertical surfaces.
Panel Wattage options include 45W, 70W, 90W, 100, 140W, 240W, 280W, 480W, & 720W.
45W panel dimensions: 34.25” x 20.13” x 1.5”
70W panel dimensions: 32.35” x 26.22” x 1.5”
90W panel dimensions: 40.25” x 26.25” x 1.5”
100W panel dimensions: 47.87” x 26.43” x 1.5”
140W panel dimensions: 44” x 38.7” x 1.5” (or may be supplied as two 70W panels).
240W panel dimensions: 64.38” x 39” 1.5”
280W panel consists of two 140W panels.
480W panel consists of two 240W panels.
720W panel consists of three 240W panels.

Control Module
Supplied with a MPPT charge controller which automatically controls the solar panel power, battery charging and lighting function and operation.
Ultra fast Maximum Power Point Tracking (MPPT).
The MPPT charge controller is typically 30% more efficient than standard PWM controllers and 10% more efficient to most other MPPT controllers.
Additional efficiency for cloudy weather and during times of reduced sun radiation.
Provides extended battery life and extra protection against excessive battery discharge and overcharge.
Low voltage detection for automatic disconnect.
Pre-programmed software for load output, dusk to dawn lighting, single timed lighting, dual timed lighting, dimming option and the ability of interfacing with motion detection, where required.
This MPPT charge controller is programmed by Solar Illuminations as per your requirements and system ability.
Lighting control features illumination from dusk to dawn (where applicable), or on at dusk for X amount of hours then off, or on at dusk for X amount of hours, then off, then back on again for X amount of hours before dawn.
Dimming option (where applicable) allows the lighting to dim at any time during the illumination time.
Battery voltage 12/24V dc auto select.
Rated charge current 10A/15A.
Operating temperature is -22 deg. F (-30 deg. C) to 140 deg. F (+60 deg. C).

Installation
Easy to install.
All connections are simply plug & play.
A pair of triangle shaped support frames are supplied for the solar panel.
Optional pole mount equipment can be purchased for battery enclosure and solar panel pole mounting.
Solar panel must be installed facing south, without any shading from trees or other tall structures.
All solar panel size requirements are based on the solar panel angled at 15 degrees plus installation location, unless requested otherwise.

Remarks
 

Subject to warranty registration, a limited 20 year solar panel warranty applies and a limited 5 year warranty on all other components (excluding batteries). Battery warranty (if applicable) is with the battery manufacturer.* Warranty registration is required (after purchase), otherwise a standard 30 day limited warranty will apply. After making your purchase, go to www.solarilluminations.com/registration to register your warranty.
Additionally, unlimited, lifetime technical support is available for all warranty registrations.

Please Note: This product is a special order and is non-returnable except in the event of a fault (during its warranty period) when the product, once returned will be repaired or replaced.

The solar panel must be installed in a location where it can receive full direct sunshine (when available) and usually set facing South at an appropriate angle (where adjustment options allow). The solar panel must not be installed in a shaded or part shaded location and never indoors. The standard specifications of the system (particularly the solar panel Wattage and battery capacity) may need to be adjusted. These components are determined by your geographic location, power consumption (LED Wattage) and the total amount of hours of illumination time required. Such changes to the standard specifications may increase or decrease the cost shown. Please contact us for more information or assistance. The illumination time is estimated and subject to various factors including (but not limited to) geographic location, seasons, temperature, weather conditions & location of product etc. The illumination time of most solar lights can reduce during winter months when the weather is poor and the days are shorter. During this time insolation hours decrease accordingly. Shorter illumination time due to one or more of the above factors does not define the product as being ‘defective’ or ‘not as described’. All solar lights must be used in a completely dark location at night time otherwise they may not illuminate. Nearby strong lighting sources or ambient lighting may affect the operation of a solar light. This does not define the product as being 'defective' or 'not as described'. Please note, if you do not install or use this product for several months the battery may discharge naturally on its own. By allowing a battery to deep discharge it may cause irreversible damage as the battery may then lose the ability to recharge or hold a full charge. Although unlikely, we reserve the right to supply this product with any minor alterations or minor changes to the specifications (shown above by text description or by photographs) due to different supplies or product batches received, incorporating such product changes made by the manufacturer, without further notice. Descriptions, specifications and photographs are updated regularly but may not be current when minor changes to a product have only recently been made.

* View our Terms, Conditions and Polices (including our Returns Policy) for further information.

Solar Lights Data
PriceFrom $820.00.
Lumen OutputFrom 665 to 3990 Lumens each.
Approximate Illumination TimeUp to 8 hours, dusk to dawn, or any other requirement.
Approximate Sign SIzeUp to 24' x 12' (7m x 3.5m).
Solar Panel WattageFrom 45 Watts.
Programable ControllerYes.